Product ID:KEL-GUARD ZINC CHROMATE/RED OXIDE PRIMER 17
MSDS Date:02/18/1988
FSC:8010
NIIN:00N022094
MSDS Number: BLWVH

KELLY-MOORE PAINT CO INC

1015 COMMERCIAL ST
SAN CARLOS, CA 94070
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 415-592-8337

Preparer: JULIAN E SCHAFER

Cage: KELLY

KELLY-MOORE PAINT CO INC

SAN CARLOS, CA 94070 US

Telephone: 415-592-8337

Cage: KELLY

2 @ 68F. (CONTAINS INGRED 3, 4, & 5)

CAS: 64742-86-5

RTECS: LX3296500

Fraction By Weight: 30-40%

CHROMIC ACID, ZINC SALT; COMPD WITH ZINC HYDROXIDE AND

CAS: 37300-23-5

RTECS: GB3300000

Fraction By Weight: < 5%

OSHA PEL 0.1 MG/M3 (CRO3)

ACGIH TLV: 0.01MG/M3(CR)

HYDROTREATED LIGHT DISTILLATE (PETROLEUM)

CAS: 64742-47-8

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

SOLVENT NAPHTHA (PETROLEUM) LIGHT AROMATIC

CAS: 64742-95-6

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ALKYL BENZENES, C10 - C12

CAS: 68515-25-3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZ, HDCHS, NAUSEA, CONFUSION,
IRRIT TO UPPER RESPIRATORY TRACT, UNCONS, SKIN & EYE IRRIT.
INTENTIONAL MISUSE BY DELIBERATEY CONC & INHALING THE CONTENTS MAY
BE HARMFUL OR FATAL. CHRONIC: PROL ONGED EXPOSURE TO HIGH VAPOR
CONC MAY RESULT IN KIDNEY OR LIVER DAMAGE. REPORTS HAVE ASSOC RPTD
& PRLNG(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OCCUPATIONAL OVEREXPOSURE TO SOLVENTS
WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:SEE YOUR PHYSICIAN FOR SPECIFIC
MEDICAL OPINION REGARDING YOUR CONDITION.

First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. EYE: FLUSH WITH LARGE VOLUMES OF WATER FOR AT LEAST 15
MIN. GET MEDICAL ATTN. SKIN: WIPE OFF WITH A RAG. WASH THOROUGHLY
WITH SOAP AND WATER. INGEST: CONSULT HOSPITAL EMERGENCY ROOM OR
POISON CONTROL CENTER IMMEDIATELY.

Flash Point:>100F,>38C
Lower Limits:1 %
Extinguishing Media:USE APPROVED CLASS B FIRE EXTINGUISHER OR
EXTINGUISHING AGENTS SUCH AS CO2, FOAM ETC.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CLOSED CONTAINER TO PREVENT PRESSURE
BUILDUP. WATER SPRAY/H2O FOG (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT SURF.(SUPP DATA

Spill Release Procedures:EXTINGUISH ALL SOURCES OF IGNITION. VENTILATE
AREA TO PVNT BUILDUP OF VAPORS WHICH MAY ACCUMULATE IN LOW AREAS.
FOR LARGE SPILLS, DIKE AREA W/ABSORBENT MATERIAL & SCOOP UP WITH
NON- SPARKING TOOLS. FO R SMALL SPILLS, SOAK UP LIQUID WITH
ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
DISCARD CONTAMINATED SHOES.

Respiratory Protection:TO AVOID BRTHG VAPS/SPRY MIST, OPEN WINDOWS AND
DOORS OR USE OTHER MEANS TO ENSURE FRESH AIR ENTRY DURING
APPLICATION AND DRYING. WEAR RESPIRATORY PROT (NIOSH/MSHA TC 23C OR
EQUIVALENT). USE PARTICLE MASK TO AVOID BREATHING SANDING DUST.
Ventilation:LOCAL EXHAUST SUFFICIENT TO KEEP TLV BELOW PRESCRIBED
LIMITS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: SHOULD BE USED CAREFULLY IN FIRE FIGHTING. THIS
PRODUCT WILL FOAT ON WATER AND CAN BE IGNITED ON THE WATER SURFACE.
EXPLO HAZ: VAPORS MAY TRAVEL ALONG THE GROUND AND BE IGNITED AT DIS
TANT LOCATION WITH POSSIBLE FLASHBACK TO THE HANDLING SITE.

HCC:F4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Density:HVR/AIR
Spec Gravity:1.08-1.44
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:50-65

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, IGNITION SOURCES.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION OR COMBUSTION AS IN WELDING OR FIRE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.